2001-2002 Audi TT Quattro 225hp AMU Engine Long Block Assembly with turbocharger. Removed from an AWD 2001 Audi TT Quattro with 63k miles that was equipped with the 225hp 1.8L engine and a 6 speed manual transmission. Engine was fully tested and good running condition. Compression tested with good results (185-180-185-185). Engine was also leak down tested with <5% leak down across all four cylinders. This motor had some oil leaks from the front timing cover and oil drain plug. We recommend replacing these gaskets prior to installation. As well as performing any recommended maintenance at this mileage that will be easier to access with the engine removed from the vehicle, such as rear main seal, front main seals, as well as various rubber hoses and gaskets. The engine oil dipstick tube did crack and disintegrate over time. The orange dip stick tube will need to be replaced prior to installation. Includes the factory turbocharger assembly as shown. Turbo is in good usable condition with no major leaks or smoking during operation. The internal compressor shaft has a very little play in the shaft. This engine is stamped with the AMU code, as shown in the second to last photo. You will need to verify that your motor has this matching stamp, otherwise it will not work for your vehicle. This stamp can be found on the front of the head casting (as shown in the photos) or on the barcode sticker located at the rear of the engine. Includes everything in the pictures, nothing more, nothing less: fuel rail, timing cover, AC compressor, Exhaust manifold, turbocharger, injectors, and injector harness. You will need to reuse some of your existing hardware and components for installation. The last photo shows the cluster's mileage from the vehicle this motor was removed from.
2001, 2002 Audi TT Quattro 225hp (w/ AMU engine code)
****Please Read- Shipping Details Below****
This item will ship on a pallet via Fedex Freight to the Continental 48 States, Mexico and Canada. Please add the item to the cart to see the exact shipping costs associated with it. There will be two options for shipping, one without a liftgate equipped truck and one with a liftgate. If you have a business address with a loading dock, forklift or other means of unloading the pallet off of the delivery truck you will not need a liftgate equipped truck for delivery. If you have a residential address or are unsure about unloading the pallet from the truck please refer to the weight of the shipment above on this listing page, so you can make the decision on whether you will need a liftgate or not. For residential deliveries Fedex will contact you, at the phone number provided, to schedule an appointment for delivery. As with all freight companies they deliver to the curb, not inside, so please plan accordingly for your delivery.
This engine comes with a 90 day warranty that begins on the day the engine is received by the buyer. The warranty covers the engine block, crankshaft, pistons, rods, bearings, oil pump, cylinder head, head gasket, camshafts, valves and lifters against any defects that prevent the engine from operating as intended from the factory or make noises consistent with damaged engine internals ( rod knock, spun bearings, etc). Every engine we list on eBay has been fully run tested, compression tested and when possible test driven to make sure it runs smoothly, makes no odd noises and does not overheat.
What is not included in the warranty is common wear and tear items such as: timing belt, water pump, thermostat, spark plugs, spark plug wires, sensors and seals. While these items were in working condition at the time of testing, their lifespan is usually shorter than the internals of the engine and are therefore not covered under warranty. If any seals or gaskets are leaking at the time the engine is being tested and removed, or any sensors broken or defective, they will be noted in the item description. No labor, diagnostic or towing costs will be covered under warranty. In the event of a warranty claim, please be prepared to supply pictures, video and/or a statement from a shop/mechanic to validate the claim. This warranty is non-transferrable. It is only applicable to the original purchaser.
Situations that will void the warranty:
Overheating of the engine. We install "heat indicator tabs" on every engine prior to shipping that show when an engine has being operated at a temperature significantly higher than normal operating temperature. If these tabs show signs of overheating, the warranty will be void. If the engine in your car is being replaced due to damage from an overheating condition please locate and fix the source of the issue prior to running your new engine.
Not running fresh oil and oil filter in the engine (these engines ship drained of all oil).
Installation of an aftermarket turbocharger, supercharger or Nitrous Oxide kit.